Hatco’s Intelligent Toast-Qwik toaster should be cleaned daily to avoid malfunctions, maintain a sanitary operation, and to preserve the finish. Daily cleaning involves four areas: conveyor chain, crumb trays and toast chute, exterior surfaces, product sensors and sensor reflectors. Monthly or as needed cleaning involves two areas: the bottom element reflector and fan filter. Remember, during all cleaning procedures, never immerse the unit in water. Perform the daily shutdown procedure as shown in the operation section of the ITQ installation and operating manual. This can be downloaded from the Hatco website at www.hatcocorp.com. Next, unplug the power cord. The toaster must be cooled down before you start. Remember to never put soap directly on the conveyor chain. To clean, manually move the chain a section at a time. Apply mild soap to a soft cloth and wipe the chain. For heavy buildup, use a scrub pad on the conveyor. Finally, use a soft cloth dampened with water to rinse the conveyor chain. Remember, the toaster must be cooled down before you start. Remove and empty the crumb trays and toast chute. Wash all with warm water and mild detergent. Rinse with water. Allow the crumb trays and toast chute to air dry. Reinstall the crumb trays and toast chute. Refer to the ITQ installation and operating manual for instructions. Wipe the exterior surfaces of the toaster with a non-abrasive damp cloth. Stubborn stains may be removed with a good stainless steel cleaner or a non-abrasive cleaner. Hard-to-reach areas should be cleaned with a small brush and mild soap. Never clean sensor covers or sensor reflectors with abrasive pads or cleaners. Clean and polish the product sensors and sensor reflectors using a mild degreaser and soft, non-abrasive cloth. Sensor reflectors are present on dual conveyor units only. The bottom element reflector inside the toasting chamber has slots that allow bread crumbs to drop through to the crumb tray. Over an extended period of use, bread crumbs may build up on the reflector and not drop through onto the tray. Here’s how to clean it. Perform the daily shutdown procedure as shown in the operation section of the ITQ installation and operating manual, and unplug the power cord. Make sure the toaster is turned off and completely cooled before you start. Wipe the crumbs onto the crumb tray using a bristle brush. Place the bristle brush through the conveyor belt and wipe to each side. Be sure to remove any bristles left behind in the toasting chamber. Finally, perform the daily cleaning procedures shown previously in this video. Two cooling fan filters are located on the bottom left side of the unit. These filters should be checked or cleaned monthly or anytime the warning light comes on. Use the following procedures to clean the filters. Make sure the toaster is turned off and cooled down before you proceed. Perform the daily shutdown procedure as shown in the operation section of the ITQ installation and operating manual, and unplug the power cord. Slide filters out of the filter housing on the bottom of the unit. Rinse the filters using hot water. Allow them to air dry completely. Slide the filters back into the filter housing. Make sure each filter slides above the filter support on each side of the housings. This concludes the training video. If you have any questions, please consult your Intelligent Toast-Qwik installation and operating manual. For service, go to www.hatcocorp.com or call 1-800-558-0607.
Copy and paste the embed code above.
To keep toasting perfect bagels, breads, English muffins, and more, your Hatco Intelligent Toast-Qwik conveyor toaster should be cleaned daily and monthly. Watch this video to learn about these two cleaning processes.
This video explains all four operating modes of Hatco's Intelligent Toast-Qwik toasters, showing you just how easy it is to create perfectly toasted products every time! Check it out to learn about more of this product's great features.
No more crawling on the floor or struggling with messy pumps to refill your counter-mounted soap dispenser! With the Kutol EZ foam counter mount soap dispenser, you get a sophisticated look and a rich, foam lather that customers will love.
The Leading Distributor of Restaurant Supplies and Equipment
Based in Lancaster, PA, WebstaurantStore is the largest online restaurant supply store serving food service professionals and individual customers worldwide. With thousands of available products and over 5.5 million orders shipped, we have everything your business needs to function at its best. Over the years we have expanded our selection of wholesale supplies and commercial equipment to include healthcare, educational, and hotel supplies.
Our focus is your convenience – order online from your laptop, desktop, or smartphone 24 hours a day, 7 days a week. Our fast shipping, low prices, and outstanding customer service make WebstaurantStore the best choice to meet all of your professional and food service supply needs.